Brontekst bekijken van Smartphone glass repair kit

[[Categorie:Tool]][[Categorie:Small]][[Categorie:electronics]]
[[Categorie:Tools]][[Categorie:Electronics tools]]
= Smartphone glass repair kit =

This kit was successfully used on Samsung Galaxy s4 mini to replace the broken glass. 

[[Bestand:Smartphone_broken.jpg|500px]]

Instructions can be found on youtube (e.g. [https://www.youtube.com/watch?v=2CZvv26-iZw here] for s4 mini)

= New glass =
Repair kit (glass + tools) ordered from Ebay. The tools are worthless, the sticker and glass are good.

= DIY Tools =
* flexible steel pry tool, necessary to lift the glass at the start in order to get the wire underneath the glass
* wire to pull between the glass and the touch sensor
[[Bestand:Tools_in_action.jpg|300px]] [[Bestand:Tools_smartphone.jpg|300px]] [[Bestand:Toolbox_smartphone.jpg|300px]]

= Process =
* Take the battery out, re-close the back lid. 
* Heat the glass to 80-100 Celsius (do not go above 100). Use the heat gun on lowest setting about 20cm above the phone. Check continuously at various spots with infrared thermometer. 
* Follow the video.
* Use tissues with acetone to remove glue leftovers
* Attach the sticker: think twice which way it will go, which sticky layer to expose first, pay attention to the camera hole etc. If not all holes are present on the sticker - apply first, then cut out holes for sensors with sharp knife/tweezers. Make sure the middle button is in the middle.

NB: It maybe better to apply the sticker to the glass first

* Place the new glass in, and you're done!

= After you are done =
* Put all the tools back in the box, put the box back in its place
* Leave your suggestions/comments, or a +1, on this wiki page